-
Inductively coupled plasmais widely used in semiconductor and display process because of its desirable characteristics such as high plasma density, simple structure and independently controllable ion energy. The driving frequency is a significant parameter that generates and maintains the plasma. However, the effects of different driving frequencies on the radial distribution of the plasma parameters are hardly investigated. So a large area cylindrical inductively coupled plasma source driven separately by 2 MHz and 13.56 MHz is investigated. In order to perform a comprehensive investigation about the effect of driving frequency, the radially resolved measurements of electron density, electron temperature and density of metastable state atoms for the argon discharge are systematically analyzed by Langmuir double probe and optical emission spectroscopy at various power values and gas pressures. It is found that input power values at high frequency (13.56 MHz) and low frequency (2 MHz) have different effects on plasma parameters. When discharge is driven at high frequency, the electron density increases obviously with the increase of power. However, when discharge is driven at low frequency, the electron temperature increases evidently with the increase of power. This can be explained by calculating the skin depths in high and low frequency discharge. When the discharge is driven at high frequency, the induced electromagnetic field is higher than that at low frequency, and the single electron obtains more energy. It is easier to ionize, so the energy is mainly used to increase the electron density. When the discharge is driven at low frequency, the skin layer is thicker, the number of heated electrons is larger, and the average energy of electrons is increased, so the energy is mainly used to raise the electron temperature. At a gas pressure of 10 Pa, the electron density shows a ‘convex’ distribution and increases with the increase of input power for both the high-frequency and low-frequency discharge. While the distributions of electron temperature are obviously different. When the discharge is driven at high frequency, the electron temperature is relatively flat in the center of the chamber and slightly increases on the edge. When the discharge is driven at low frequency, the electron temperature gradually decreases along the radial position. This is due to the one-step ionization in the high-frequency discharge and the two-step ionization in the low-frequency discharge. In order to prove that the low-frequency discharge is dominated by two-step ionization, the spectral intensities of the argon plasma under the same discharge conditions are diagnosed by optical emission spectroscopy. The number density of metastable states is calculated by the branch ratio method. The results are consistent with the analyses. At a gas pressure of 100 Pa, the electron density increases and then decreases with the increase of radial distance, and the overall distribution shows a " saddle shape” for high frequency and also for low frequency discharge. Although the uniformity of electron density improves with the gas pressure, the uniformity at low frequency is better than that at high frequency. The reason can be attributed to the fact that the skin layer of low frequency is thicker and the heating area is wider.
-
Keywords:
- inductively coupled plasma /
- Langmuir double probe /
- optical emission spectroscopy /
- plasma parameters
[1] 迈克尔A.力伯曼, 阿伦J.里登伯格 著(蒲以康 译) 2004 等离子体放电原理与材料处理(北京: 科学出版社)第1−19页
Lieberman M A, Lichtenberg A J(translated by Pu Y K) 2004 Principles of Plasma Discharge and Materials Processing (Beijing: Science Press) pp1−19 (in Chinese)
[2] 帕斯卡 夏伯特 著(王友年 译) 2015 射频等离子体物理学(北京: 科学出版社)第1−15页
Chabert P(translated by Wang Y N) 2015 Physics of Radio-Frequency Plasmas (Beijing: Science Press) pp1−15 (in Chinese)
[3] Xu S, Ostrikov K N, Li Y, Tsakadze E L, Jones I R 2000 Phys. Plasmas 45 20
[4] Saehoon U, Kyong-Ho L, Chang H Y, Chung C W 2004 Phys. Plasmas 11 4830
Google Scholar
[5] Kim J H, Hwang H J, Kim D H, Cho J H, Chung C W 2015 J. Appl. Phys. 117 153302
Google Scholar
[6] 丁振峰, 袁国玉, 高巍, 孙景超 2007 57 4304
Ding Z F, Yuan G Y, Gao W, Sun J C 2007 Acta Phys. Sin. 57 4304
[7] 高飞 2011 博士学位论文(大连: 大连理工大学)
Gao F 2011 Ph. D. Dissertation (Dalian: Dalian University of Technology) (in Chinese)
[8] 赵书霞 2011 博士学位论文(大连: 大连理工大学)
Zhao S X 2010 Ph. D. Dissertation (Dalian: Dalian University of Technology) (in Chinese)
[9] Godyak V A, Alexandrovich B M 2004 Phys. Plasmas 11 3553
Google Scholar
[10] Lee H C, Chung C W 2015 Phys. Plasmas 22 053505
Google Scholar
[11] Lee H C, Chung C W 2013 Phys. Plasmas 20 101607
Google Scholar
[12] Jun H S, Chang H Y 2007 Appl. Phys. Lett. 92 041501
[13] Gao F, Zhang Y R, Li H, Liu Y, Wang Y N 2017 Phys. Plasmas 24 073508
Google Scholar
[14] Liu F, Ren C S, Wang Y N, Qi X L, Ma T C 2006 Vacuum 81 221
Google Scholar
[15] Hua Y, Song J, Hao Z Y 2018 Plasma Sci. Technol. 20 065402
Google Scholar
[16] Hua Y, Song J, Hao Z Y, Zhang G L 2018 Plasma Sci. Technol. 20 014005
Google Scholar
[17] 刘耀泽 2016 硕士学位论文(哈尔滨: 哈尔滨工业大学)
Liu Y Z 2016 M. S. Thesis (Harbin: Harbin Institute of Technology) (in Chinese)
[18] 张健 2006 硕士学位论文(大连: 大连理工大学)
Zhang J 2006 M. S. Thesis (Dalian: Dalian University of Technology) (in Chinese)
[19] 齐雪莲 2008 博士学位论文(大连: 大连理工大学)
Qi X L 2008 Ph. D. Dissertation (Dalian: Dalian University of Technology) (in Chinese)
[20] Daltrini A M, Moshkalev S A, Monteiro M J R, Besseler E, Kostryukov A 2007 J. Appl. Phys. 101 073309
Google Scholar
[21] Moshkalev S A, Steen P G, Gomez S, Graham W G 1999 Appl. Phys. Lett. 75 328
Google Scholar
[22] 韩雪 2015 硕士学位论文(哈尔滨: 哈尔滨工业大学)
Han X 2015 M. S. Thesis (Harbin: Harbin Institute of Technology) (in Chinese)
[23] Daltrini A M, Moshkalev S A,Morgan T J 2008 Appl. Phys. Lett. 92 061504
Google Scholar
[24] Zhu X M, Pu Y K 2010 J. Phys. D 43 015204
Google Scholar
[25] Czerwiec T,Graves D B 2004 J. Phys. D 37 2827
Google Scholar
[26] 刘阳 2017 硕士学位论文(大连: 大连理工大学)
Liu Y 2017 M. S. Thesis (Dalian: Dalian University of Technology) (in Chinese)
[27] Li H, Liu Y, Zhang Y R, Gao F, Wang Y N 2017 J. Appl. Phys. 121 23302
Google Scholar
[28] Lee H C, Seo B H, Kwon D C, Kim J H, Seong D J, Oh S J, Chung C W, You K H, Shin C H 2017 Appl. Phys. Lett. 110 014106
Google Scholar
[29] Lee H C 2018 Phys. Plasmas 5 011108
Google Scholar
[30] Lee H C, Lee M H, Chung C W 2010 Appl. Phys. Lett. 96 041503
Google Scholar
[31] Setsuhara Y, Tsukiyama D, Takenaka K 2008 Surface & Coatings Technology 202 5238
-
图 1 柱状感性耦合等离子体源的实验装置图
Figure 1. A schematic diagram of the cylindrical inductively coupled plasma reactor.
图 2 频率为13.56 MHz, 气压为10 Pa, 输入功率为400 W, 腔室中心(r = 0 cm)处氩等离子体发射光谱全谱
Figure 2. Argon plasma emission spectroscopy at 10 Pa for 13.56 MHz radio-frequency discharge. The radio-frequency power is fixed at 400 W and the measurement plane is r = 0 cm.
图 3 气压为10 Pa时, 在z = 10 cm, r = 0 cm处, 13.56 MHz/2 MHz放电中等离子体参数随功率的变化 (a)电子密度; (b)电子温度
Figure 3. (a) The electron density and (b) electron temperature of 13.56 MHz/2 MHz discharge at different power. The gas pressure is fixed at 10 Pa and the measurement position is z = 10 cm, r = 0 cm.
图 4 气压为10 Pa时, 13.56 MHz/2 MHz放电中趋肤深度随功率的变化
Figure 4. The skin depth versus input power for 13.56 MHz/2 MHz discharge at 10 Pa.
图 5 气压为10 Pa时, z = 10 cm处, 13.56 MHz/2 MHz放电中电子密度的径向分布 (a)高频13.56 MHz; (b)低频2 MHz
Figure 5. The radial distribution profiles of electron density for (a) 13.56 MHz and (b) 2 MHz discharge. The gas pressure is fixed at 10 Pa and the measurement plane is z = 10 cm.
图 6 气压为10 Pa时, 高低频放电中电子温度的径向分布 (a)高频13.56 MHz; (b)低频2 MHz
Figure 6. The radial distribution profiles of electron temperature for (a) 13.56 MHz and (b) 2 MHz discharge. The gas pressure is fixed at 10 Pa and the measurement plane is z = 10 cm.
图 7 气压为10 Pa时, 高低频放电中亚稳态的径向分布 (a)高频13.56 MHz; (b)低频2 MHz
Figure 7. The radial distribution profiles of metastable states for (a) 13.56 MHz and (b) 2 MHz discharge at 10 Pa.
图 8 气压为100 Pa时高低频放电中电子密度的径向分布 (a)频率为13.56 MHz; (b)频率为2 MHz
Figure 8. The radial distribution profiles of electron density (a) 13.56 MHz and (b) 2 MHz discharge. The gas pressure is fixed at 100 Pa and the measurement plane is z = 10 cm.
图 9 气压为10 Pa和100 Pa时, 在z = 10 cm处, 高低频放电中径向不均匀度随功率的变化
Figure 9. Thenonuniformity at different power for 13.56 MHz/2 MHz discharge. The gas pressure is fixed at 10 Pa and 100 Pa, the measurement plane is z = 10 cm.
图 10 气压为10 Pa和100 Pa时, 13.56 MHz/2 MHz放电中电子能量弛豫长度随功率的变化
Figure 10. The electron energy relaxation length versus input power for 13.56 MHz/2 MHz discharge. The gas pressure is fixed at 10 Pa and 100 Pa.
图 11 气压为100 Pa时高低频放电中电子温度的径向分布 (a)高频13.56 MHz; (b)低频2 MHz
Figure 11. The radial distribution profiles of electron temperature (a) 13.56 MHz and (b) 2 MHz discharge. The gas pressure is fixed at 100 Pa and the measurement plane is z = 10 cm.
-
[1] 迈克尔A.力伯曼, 阿伦J.里登伯格 著(蒲以康 译) 2004 等离子体放电原理与材料处理(北京: 科学出版社)第1−19页
Lieberman M A, Lichtenberg A J(translated by Pu Y K) 2004 Principles of Plasma Discharge and Materials Processing (Beijing: Science Press) pp1−19 (in Chinese)
[2] 帕斯卡 夏伯特 著(王友年 译) 2015 射频等离子体物理学(北京: 科学出版社)第1−15页
Chabert P(translated by Wang Y N) 2015 Physics of Radio-Frequency Plasmas (Beijing: Science Press) pp1−15 (in Chinese)
[3] Xu S, Ostrikov K N, Li Y, Tsakadze E L, Jones I R 2000 Phys. Plasmas 45 20
[4] Saehoon U, Kyong-Ho L, Chang H Y, Chung C W 2004 Phys. Plasmas 11 4830
Google Scholar
[5] Kim J H, Hwang H J, Kim D H, Cho J H, Chung C W 2015 J. Appl. Phys. 117 153302
Google Scholar
[6] 丁振峰, 袁国玉, 高巍, 孙景超 2007 57 4304
Ding Z F, Yuan G Y, Gao W, Sun J C 2007 Acta Phys. Sin. 57 4304
[7] 高飞 2011 博士学位论文(大连: 大连理工大学)
Gao F 2011 Ph. D. Dissertation (Dalian: Dalian University of Technology) (in Chinese)
[8] 赵书霞 2011 博士学位论文(大连: 大连理工大学)
Zhao S X 2010 Ph. D. Dissertation (Dalian: Dalian University of Technology) (in Chinese)
[9] Godyak V A, Alexandrovich B M 2004 Phys. Plasmas 11 3553
Google Scholar
[10] Lee H C, Chung C W 2015 Phys. Plasmas 22 053505
Google Scholar
[11] Lee H C, Chung C W 2013 Phys. Plasmas 20 101607
Google Scholar
[12] Jun H S, Chang H Y 2007 Appl. Phys. Lett. 92 041501
[13] Gao F, Zhang Y R, Li H, Liu Y, Wang Y N 2017 Phys. Plasmas 24 073508
Google Scholar
[14] Liu F, Ren C S, Wang Y N, Qi X L, Ma T C 2006 Vacuum 81 221
Google Scholar
[15] Hua Y, Song J, Hao Z Y 2018 Plasma Sci. Technol. 20 065402
Google Scholar
[16] Hua Y, Song J, Hao Z Y, Zhang G L 2018 Plasma Sci. Technol. 20 014005
Google Scholar
[17] 刘耀泽 2016 硕士学位论文(哈尔滨: 哈尔滨工业大学)
Liu Y Z 2016 M. S. Thesis (Harbin: Harbin Institute of Technology) (in Chinese)
[18] 张健 2006 硕士学位论文(大连: 大连理工大学)
Zhang J 2006 M. S. Thesis (Dalian: Dalian University of Technology) (in Chinese)
[19] 齐雪莲 2008 博士学位论文(大连: 大连理工大学)
Qi X L 2008 Ph. D. Dissertation (Dalian: Dalian University of Technology) (in Chinese)
[20] Daltrini A M, Moshkalev S A, Monteiro M J R, Besseler E, Kostryukov A 2007 J. Appl. Phys. 101 073309
Google Scholar
[21] Moshkalev S A, Steen P G, Gomez S, Graham W G 1999 Appl. Phys. Lett. 75 328
Google Scholar
[22] 韩雪 2015 硕士学位论文(哈尔滨: 哈尔滨工业大学)
Han X 2015 M. S. Thesis (Harbin: Harbin Institute of Technology) (in Chinese)
[23] Daltrini A M, Moshkalev S A,Morgan T J 2008 Appl. Phys. Lett. 92 061504
Google Scholar
[24] Zhu X M, Pu Y K 2010 J. Phys. D 43 015204
Google Scholar
[25] Czerwiec T,Graves D B 2004 J. Phys. D 37 2827
Google Scholar
[26] 刘阳 2017 硕士学位论文(大连: 大连理工大学)
Liu Y 2017 M. S. Thesis (Dalian: Dalian University of Technology) (in Chinese)
[27] Li H, Liu Y, Zhang Y R, Gao F, Wang Y N 2017 J. Appl. Phys. 121 23302
Google Scholar
[28] Lee H C, Seo B H, Kwon D C, Kim J H, Seong D J, Oh S J, Chung C W, You K H, Shin C H 2017 Appl. Phys. Lett. 110 014106
Google Scholar
[29] Lee H C 2018 Phys. Plasmas 5 011108
Google Scholar
[30] Lee H C, Lee M H, Chung C W 2010 Appl. Phys. Lett. 96 041503
Google Scholar
[31] Setsuhara Y, Tsukiyama D, Takenaka K 2008 Surface & Coatings Technology 202 5238
DownLoad:
Catalog
Metrics
- Abstract views: 9218
- PDF Downloads: 151
- Cited By: 0
