阶梯AlGaN外延新型Al0.25Ga0.75N/GaN HEMTs击穿特性分析

段宝兴; 杨银堂

doi:10.7498/aps.63.057302

摘要

为了优化AlGaN/GaN HEMTs器件表面电场，提高击穿电压，本文首次提出了一种新型阶梯AlGaN/GaN HEMTs结构. 新结构利用AlGaN/GaN异质结形成的2DEG浓度随外延AlGaN层厚度降低而减小的规律，通过减薄靠近栅边缘外延的AlGaN层，使沟道2DEG浓度分区，形成栅边缘低浓度2DEG区，低的2DEG使阶梯AlGaN交界出现新的电场峰，新电场峰的出现有效降低了栅边缘的高峰电场，优化了AlGaN/GaN HEMTs器件的表面电场分布，使器件击穿电压从传统结构的446 V，提高到新结构的640 V. 为了获得与实际测试结果一致的击穿曲线，本文在GaN缓冲层中设定了一定浓度的受主型缺陷，通过仿真分析验证了国际上外延GaN缓冲层时掺入受主型离子的原因，并通过仿真分析获得了与实际测试结果一致的击穿曲线.

关键词:

Abstract

In order to optimize the surface electric field of AlGaN/GaN high electron mobility transistors (HEMTs), a novel AlGaN/GaN HEMT has been grown with a step AlGaN layer, made for the first time as far as we know, to improve the breakdown voltage. The discipline of the 2DEG concentration varying with the thickness of the AlGaN epitaxy layer has been applied to the new AlGaN/GaN HEMTs with AlGaN/GaN heterostructure. By thinning the AlGaN layer near the gate edge, the 2DEG concentration in the channel is made to form the low concentration region near the gate edge. New electric field peak has appeared at the corner of the step AlGaN layer. The high electric field has been decreased effectively due to the emergence of new electric field peak; this optimizes the surface electric field of the new AlGaN/GaN HEMTs. Then the breakdown voltage is improved to 640 V in the new AlGaN/GaN HEMTs with the step AlGaN layer as compared with 446 V for the conventional structure. In order to let the breakdown curve consistent with the test results, a certain concentration of the acceptor-like traps is added to the GaN buffer to capture the leaking current coming from the source electrode. Simulation results verify the causes for doping acceptor type ions to the GaN buffer, given by foreign researchers. The breakdown curves have been obtained which are consistent with the test results in this paper.

Keywords:

作者及机构信息

1.
西安电子科技大学微电子学院宽禁带半导体材料与器件教育部重点实验室, 西安 710071

基金项目: 国家重点基础研究发展计划（批准号：2014CB339900）、国家自然科学基金重点项目（批准号：61234006）和国家自然科学基金青年科学基金（批准号：61106076）资助的课题.

Authors and contacts

1.
Key Laboratory of the Ministry of Education for Wide Band-Gap Semiconductor Materials and Devices, School of Microelectronics, Xidian University, Xi'an 710071, China

Funds: Project supported by the State Key Development Program for Basic Research of China (Grant No. 2014CB339900), the National Natural Science Foundation of China (Grant No. 61234006), and the Young Scientists Fund of the National Natural Science Foundation of China (Grant No. 61106076).

参考文献

[1]	Kamath A, Patil T, Adari R, Bhattacharya I, Ganguly S, Aldhaheri R W, Hussain M A, Dipankar Saha 2012 IEEE Electron Device Lett. 33 1690
[2]	Hidetoshi Ishida, Daisuke Shibata, Manabu Yanagihara, Yasuhiro Uemoto, Hisayoshi Matsuo, Tetsuzo Ueda, Tsuyaoshi Tanaka, Daisuke Ueda 2008 IEEE Transactions on Electron Devices 29 1087
[3]	Tongde Huang, Xueliang Zhu, Ka Ming Wong, Kei May Lau 2012 IEEE Electron Device Lett. 33 212
[4]	Corrion A L, Poblenz C, Wu F, Speck J S 2008 Journal of Appl Phy 130 093529-1
[5]	Hidetoshi I, Daisuke S, Manabu Y, Yasuhiro U, Hisayoshi M, Tetsuzo U, Tsuyoshi T, Daisuke U 2008 IEEE Electron Device Lett. 29 1087
[6]	Chunhua Zhou, Qimeng Jiang, Sen Huang, Chen K J 2012 IEEE Electron Device Lett. 33 1132
[7]	Corrion A L, Poblenz C, Wu F, Speck J S 2008 Journal of Appl. Phys. 130 093529
[8]	Lee J H, Yoo J K, Kang H S, Lee J H 2012 IEEE Electron Device Lett. 33 1171
[9]	Lee H S, Daniel Piedra, Min Sun, Xiang Gao, Shiping Guo, Tomas Palacios 2012 IEEE Electron Device Lett. 33 982
[10]	Duan B X, Yang Y T 2012 Sci. China Inf. Sci. 55 473
[11]	Duan B X, Yang Y T 2012 Micro & Nano Letter 7 9
[12]	Subramaniam Arulkumaran, Takashi Egawa, Lawrence Selvaraj, Hiroyasu Ishikawa 2006 Japanese Jouranl of Applied Physics 45 L220
[13]	Benbakhti B, Rousseau M, De Jaeger J C 2007 Microelectronics Jouranl 38 7
[14]	Jha S, Jelenkovic E V, Pejovic M M, Ristic G S, Pejovic M, Tong K Y, Surya C, Bello I, Zhang W J 2009 Microelectronic Engineering 86 37
[15]	Arulkumaran S, Liu Z H, Ng G I, Cheong W C, Zeng R, Bu J, Wang H, Radhakrishnan K, Tan C L 2007 Thin Solid Films. 515 4517
[16]	Chen X B, Johnny K O S 2001 IEEE Transactions on Electron Devices 48 344
[17]	Duan B X, Zhang B, Li Z J 2006 IEEE Electron Device Lett. 27 377
[18]	Duan B X, Yang Y T, Zhang B, Hong X F 2009 IEEE Electron Device Lett. 30 1329
[19]	Duan B X, Yang Y T, Zhang B 2009 IEEE Electron Device Lett. 30 305
[20]	Duan B X, Yang Y T 2011 IEEE TRANSACTIONS ON Electron Devices 58 2057
[21]	Duan B X, Yang Y T, Zhang B 2010 Solid-State Electronics 54 685
[22]	Duan B X, Yang Y T, Chen K J 2012 Acta Phys. Sin. 61 247302
[23]	Duan B X, Yang Y T, Kevin J. Chen 2012 Acta Phys. Sin. 61 227302
[24]	Udrea F, Popescu A, Milne W I 1998 Electronics Letters 34 808
[25]	Smorchkova I P, Elsass C R, Ibbetson J P, Heying B, Fini P, DenBaars S P, Speck J S, Mishra U K 1999 Journal of Applied Physics 86 4520
[26]	Yifei Zhang, Smorchkova I P, Elsass C R, Stacia Keller, Ibbetson J P, Jasprit Singh 2000 Appl. Phys. Lett. 87 7981
[27]	Ibbetson J P, Fini P T, Ness K D, DenBaars S P, Speck J S, Mishra U K 2000 Appl. Phys. Lett. 77 250
[28]	Heikman S, Keller S, DenBaars S P, Mishra U K 2002 Appl. Phys. Lett. 81 439
[29]	Tang H, Webb J B, Bardwell J A, Raymond S, Salzman J, Uzan-Saguy C 2001 Appl. Phys. Lett. 78 757
[30]	Webb J B, Tang H, Rolfe S, Bardwell J A 1999 Appl. Phys. Lett. 75 953
[31]	Katzer D S, Storm D F, Binari S C, Roussos J A, Shanabrook B V, Glaser E R 2003 J. Cryst. Growth. 251 481
[32]	Poblenz C, Waltereit P, Rajan S, Heikman S, Mishra U K, Speck J S 2004 J. Vac. Sci. Technol. B 22 114

施引文献

[1]	Kamath A, Patil T, Adari R, Bhattacharya I, Ganguly S, Aldhaheri R W, Hussain M A, Dipankar Saha 2012 IEEE Electron Device Lett. 33 1690
[2]	Hidetoshi Ishida, Daisuke Shibata, Manabu Yanagihara, Yasuhiro Uemoto, Hisayoshi Matsuo, Tetsuzo Ueda, Tsuyaoshi Tanaka, Daisuke Ueda 2008 IEEE Transactions on Electron Devices 29 1087
[3]	Tongde Huang, Xueliang Zhu, Ka Ming Wong, Kei May Lau 2012 IEEE Electron Device Lett. 33 212
[4]	Corrion A L, Poblenz C, Wu F, Speck J S 2008 Journal of Appl Phy 130 093529-1
[5]	Hidetoshi I, Daisuke S, Manabu Y, Yasuhiro U, Hisayoshi M, Tetsuzo U, Tsuyoshi T, Daisuke U 2008 IEEE Electron Device Lett. 29 1087
[6]	Chunhua Zhou, Qimeng Jiang, Sen Huang, Chen K J 2012 IEEE Electron Device Lett. 33 1132
[7]	Corrion A L, Poblenz C, Wu F, Speck J S 2008 Journal of Appl. Phys. 130 093529
[8]	Lee J H, Yoo J K, Kang H S, Lee J H 2012 IEEE Electron Device Lett. 33 1171
[9]	Lee H S, Daniel Piedra, Min Sun, Xiang Gao, Shiping Guo, Tomas Palacios 2012 IEEE Electron Device Lett. 33 982
[10]	Duan B X, Yang Y T 2012 Sci. China Inf. Sci. 55 473
[11]	Duan B X, Yang Y T 2012 Micro & Nano Letter 7 9
[12]	Subramaniam Arulkumaran, Takashi Egawa, Lawrence Selvaraj, Hiroyasu Ishikawa 2006 Japanese Jouranl of Applied Physics 45 L220
[13]	Benbakhti B, Rousseau M, De Jaeger J C 2007 Microelectronics Jouranl 38 7
[14]	Jha S, Jelenkovic E V, Pejovic M M, Ristic G S, Pejovic M, Tong K Y, Surya C, Bello I, Zhang W J 2009 Microelectronic Engineering 86 37
[15]	Arulkumaran S, Liu Z H, Ng G I, Cheong W C, Zeng R, Bu J, Wang H, Radhakrishnan K, Tan C L 2007 Thin Solid Films. 515 4517
[16]	Chen X B, Johnny K O S 2001 IEEE Transactions on Electron Devices 48 344
[17]	Duan B X, Zhang B, Li Z J 2006 IEEE Electron Device Lett. 27 377
[18]	Duan B X, Yang Y T, Zhang B, Hong X F 2009 IEEE Electron Device Lett. 30 1329
[19]	Duan B X, Yang Y T, Zhang B 2009 IEEE Electron Device Lett. 30 305
[20]	Duan B X, Yang Y T 2011 IEEE TRANSACTIONS ON Electron Devices 58 2057
[21]	Duan B X, Yang Y T, Zhang B 2010 Solid-State Electronics 54 685
[22]	Duan B X, Yang Y T, Chen K J 2012 Acta Phys. Sin. 61 247302
[23]	Duan B X, Yang Y T, Kevin J. Chen 2012 Acta Phys. Sin. 61 227302
[24]	Udrea F, Popescu A, Milne W I 1998 Electronics Letters 34 808
[25]	Smorchkova I P, Elsass C R, Ibbetson J P, Heying B, Fini P, DenBaars S P, Speck J S, Mishra U K 1999 Journal of Applied Physics 86 4520
[26]	Yifei Zhang, Smorchkova I P, Elsass C R, Stacia Keller, Ibbetson J P, Jasprit Singh 2000 Appl. Phys. Lett. 87 7981
[27]	Ibbetson J P, Fini P T, Ness K D, DenBaars S P, Speck J S, Mishra U K 2000 Appl. Phys. Lett. 77 250
[28]	Heikman S, Keller S, DenBaars S P, Mishra U K 2002 Appl. Phys. Lett. 81 439
[29]	Tang H, Webb J B, Bardwell J A, Raymond S, Salzman J, Uzan-Saguy C 2001 Appl. Phys. Lett. 78 757
[30]	Webb J B, Tang H, Rolfe S, Bardwell J A 1999 Appl. Phys. Lett. 75 953
[31]	Katzer D S, Storm D F, Binari S C, Roussos J A, Shanabrook B V, Glaser E R 2003 J. Cryst. Growth. 251 481
[32]	Poblenz C, Waltereit P, Rajan S, Heikman S, Mishra U K, Speck J S 2004 J. Vac. Sci. Technol. B 22 114

[1]	武鹏, 李若晗, 张涛, 张进成, 郝跃. AlGaN/GaN肖特基二极管阳极后退火界面态修复技术. , 2023, 72(19): 198501. doi: 10.7498/aps.72.20230553
[2]	董世剑, 郭红霞, 马武英, 吕玲, 潘霄宇, 雷志锋, 岳少忠, 郝蕊静, 琚安安, 钟向丽, 欧阳晓平. AlGaN/GaN高电子迁移率晶体管器件电离辐照损伤机理及偏置相关性研究. , 2020, 69(7): 078501. doi: 10.7498/aps.69.20191557
[3]	郝蕊静, 郭红霞, 潘霄宇, 吕玲, 雷志锋, 李波, 钟向丽, 欧阳晓平, 董世剑. AlGaN/GaN高电子迁移率晶体管器件中子位移损伤效应及机理. , 2020, 69(20): 207301. doi: 10.7498/aps.69.20200714
[4]	刘静, 王琳倩, 黄忠孝. 基于凹槽结构抑制AlGaN/GaN高电子迁移率晶体管电流崩塌效应. , 2019, 68(24): 248501. doi: 10.7498/aps.68.20191311
[5]	唐文昕, 郝荣晖, 陈扶, 于国浩, 张宝顺. 1000 V p-GaN混合阳极AlGaN/GaN二极管. , 2018, 67(19): 198501. doi: 10.7498/aps.67.20181208
[6]	张力, 林志宇, 罗俊, 王树龙, 张进成, 郝跃, 戴扬, 陈大正, 郭立新. 具有p-GaN岛状埋层耐压结构的横向AlGaN/GaN高电子迁移率晶体管. , 2017, 66(24): 247302. doi: 10.7498/aps.66.247302
[7]	袁嵩, 段宝兴, 袁小宁, 马建冲, 李春来, 曹震, 郭海军, 杨银堂. 阶梯AlGaN外延新型Al0.25Ga0.75N/GaNHEMTs器件实验研究. , 2015, 64(23): 237302. doi: 10.7498/aps.64.237302
[8]	段宝兴, 曹震, 袁小宁, 杨银堂. 具有N型缓冲层REBULF Super Junction LDMOS. , 2014, 63(22): 227302. doi: 10.7498/aps.63.227302
[9]	任舰, 闫大为, 顾晓峰. AlGaN/GaN 高电子迁移率晶体管漏电流退化机理研究. , 2013, 62(15): 157202. doi: 10.7498/aps.62.157202
[10]	段宝兴, 杨银堂, Kevin J. Chen. 新型Si3N4层部分固定正电荷AlGaN/GaN HEMTs器件耐压分析. , 2012, 61(24): 247302. doi: 10.7498/aps.61.247302
[11]	马骥刚, 马晓华, 张会龙, 曹梦逸, 张凯, 李文雯, 郭星, 廖雪阳, 陈伟伟, 郝跃. AlGaN/GaN高电子迁移率晶体管中kink效应的半经验模型. , 2012, 61(4): 047301. doi: 10.7498/aps.61.047301
[12]	段宝兴, 杨银堂, 陈敬. F离子注入新型Al0.25Ga0.75 N/GaN HEMT 器件耐压分析. , 2012, 61(22): 227302. doi: 10.7498/aps.61.227302
[13]	王冲, 全思, 马晓华, 郝跃, 张进城, 毛维. 增强型AlGaN/GaN高电子迁移率晶体管高温退火研究. , 2010, 59(10): 7333-7337. doi: 10.7498/aps.59.7333
[14]	王冲, 全思, 张金凤, 郝跃, 冯倩, 陈军峰. AlGaN/GaN槽栅HEMT模拟与实验研究. , 2009, 58(3): 1966-1970. doi: 10.7498/aps.58.1966
[15]	刘林杰, 岳远征, 张进城, 马晓华, 董作典, 郝跃. Al2O3绝缘栅AlGaN/GaN MOS-HEMT器件温度特性研究. , 2009, 58(1): 536-540. doi: 10.7498/aps.58.536
[16]	张进成, 郑鹏天, 董作典, 段焕涛, 倪金玉, 张金凤, 郝跃. 背势垒层结构对AlGaN/GaN双异质结载流子分布特性的影响. , 2009, 58(5): 3409-3415. doi: 10.7498/aps.58.3409
[17]	魏巍, 郝跃, 冯倩, 张进城, 张金凤. AlGaN/GaN场板结构高电子迁移率晶体管的场板尺寸优化分析. , 2008, 57(4): 2456-2461. doi: 10.7498/aps.57.2456
[18]	李琦, 李肇基, 张波. 表面注入P-top区double RESURF功率器件表面电场模型. , 2007, 56(11): 6660-6665. doi: 10.7498/aps.56.6660
[19]	郭亮良, 冯倩, 郝跃, 杨燕. 高击穿电压的AlGaN/GaN FP-HEMT研究与分析. , 2007, 56(5): 2895-2899. doi: 10.7498/aps.56.2895
[20]	王冲, 冯倩, 郝跃, 万辉. AlGaN/GaN异质结Ni/Au肖特基表面处理及退火研究. , 2006, 55(11): 6085-6089. doi: 10.7498/aps.55.6085

计量

文章访问数: 6777
PDF下载量: 553
被引次数: 0

姓名
邮箱
手机号码
标题
留言内容
验证码

搜索

留言板