直拉单晶硅中洁净区形成后铜沉淀行为的研究

张光超; 徐进

doi:10.7498/aps.62.076103

摘要

本文研究了直拉单晶硅中形成洁净区后过渡族金属杂质铜的沉淀行为. 样品经过高低高三步常规热处理形成洁净区后, 在不同温度下引入杂质铜, 然后对样品分别进行普通热处理和快速热处理, 通过腐蚀和光学显微镜研究发现, 在700 ℃引入铜杂质后经过普通热处理和快速热处理都不会破坏洁净区, 在900 ℃和1100 ℃引入铜杂质后经过普通热处理不会破坏洁净区, 而经过快速热处理会破坏洁净区. 研究表明, 快速热处理可以使硅片体内产生大量的空位, 空位的外扩散是破坏洁净区的主要原因.

关键词:

直拉单晶硅 /
铜沉淀 /
洁净区

Abstract

The precipitation behavior of copper in denuded zone (DZ) of Czochralski silicon has been systematically investigated by means of etching and optical microscopy (OM). Firstly, the samples were treated in a conventional furnace by high-low-high annealing for the formation of denuded zone. Subsequently, copper contamination was introduced at different temperatures. Finally, samples were treated with rapid thermal annealing (RTA) and conventional furnace annealing separately. It was found that, copper precipitates could be observed in DZ through OM only in the samples which experienced RTA followed by contamination in 900 ℃ and 1100 ℃. This indicates that the out-diffusion of vacancy which is produced in the process of RTA is the main cause for the copper precipitation in DZ.

Keywords:

作者及机构信息

张光超¹,
徐进^1,2

1.
厦门大学材料学院, 厦门 361005;

2.
浙江大学硅材料国家重点实验室, 杭州 310027

基金项目: 国家自然科学基金 (批准号: 50902116)、硅材料国家重点实验室开放基金(批准号: SKL2012-17)和福建省高等学校新世纪优秀人才支持计划资助的课题.

Authors and contacts

Zhang Guang-Chao¹,
Xu Jin^1,2

1.
College of Materials, Xiamen University, Xiamen 361005, China;

2.
State Key Laboratory of Silicon Materials, Zhejiang University, Hangzhou 310027, China

Funds: Project supported by the National Natural Science Foundation of China (Grant No. 50902116), the Opening Project of State Key Laboratory of Silicon Materials (Grant No. SKL2012-17), and the Prgram for New Century Excellent Talents in Fujian Province University.

参考文献

[1]	ThomPson S, Parthasarathy S 2006 MaterialsThday 9 20
[2]	Liu B C, Huang T Y 2006 China Materials Engineering Dictionary (Vol. 11) (beijing: Chemical Industry Press) p116-119 (in Chinese) [柳百成, 黄天佑 2006 中国材料工程大典(11 卷) (北京: 化学工业出版社) 第116–119页]
[3]	Bergholz W, Gilles D 2000 Phys. Stat. Sol. (b) 5 222
[4]	Shimura F, Willardson R K 1994 Academic Press 41
[5]	Isomae S, Aoki S, Watanabe K 1983 J. Appl. Phys. Lett. 55 817
[6]	Broniatowski A 1989 Phys. Rev. Lett. 62 3074
[7]	Davis J R, Rohatgi A 1980 J. Cryst. Growth. 75 67
[8]	Bains S K, Griffiths D P, Wilkes J G, Series R W, Barraclough K G 1990 J. Electrochem. Soc. 137 647
[9]	Hamet J F, Abdelaoui R, Nouet G 1990 J. Appl. Phys. 68 638
[10]	Xu J, Li F L, Yang D R 2007 Acta Phy. Sin. 4113 56 (in Chinese) [徐进, 李福龙, 杨德仁 2007 56 4113]
[11]	Zhu X, Yang D R, Li M, Chen T, Wang L, Que D L 2008 Chin. Phys. Lett. 25 651
[12]	Seibt M, Griess M, Istraov A A, Hedemann H, Sattler A 1998 Phys. Stat. Sol. (a) 166 171
[13]	Istratov A A, Weber E R 1998 Appl. Phys. A 66 123
[14]	Sachdeva R, Istratov A A, Weber E R 2001 Appl. Phys. Lett. 79 2937
[15]	Istratov A A, Weber E R 2002 J. Electrochem. Soc. 79 2397
[16]	Goetzberger A, Shockley W 1960 J. Appl. Phys. 31 1821
[17]	Miyazaki M, Sano M, Sumita S, Fujino N 1991 Jpn. J. Appl. Phys. 30 L295
[18]	Honda K, Ohsawa A, Toyokura N 1984 Appl. Phys. Lett. 45 270
[19]	Hiramoto K, Sano M, Sadamitsu S, Fujino N 1989 Jpn. J. Appl. Phys. 28 L2109
[20]	Wendt H, Cerva H, Lehmann V, Pamler W 1989 J. Appl. Phys. 65 2402
[21]	Istratov A A, Flink C, Hieslmair H 2000 Mater. Sci. Eng. B 72 99
[22]	Andrei A, Istratov A A, Weber E R 2002 J. Electrochem. Soc. G21 149
[23]	Xi Z Q, Yang D R, Xu J 2003 Appl. Phys. Lett. 83 3048
[24]	Istratova A A, Weber E R 1998 Appl. Phys. A: Mater. Sci. Pro. A66 123
[25]	Tan T Y, Gardner E E, Tice W K 1977 Appl. Phys. Lett. 30 175
[26]	Nakamura K, Saishoji T, Kubota T, Iida T, Shimanuki Y, Kotooka T 1997 J. Cryst. Growth. 180 31
[27]	Frewen T A, Sinno T 2006 Appl. Phys. Lett. 89 191903
[28]	Strunk H, Gosele U, Kolbesen B O 1979 Appl. Phys. Lett. 34 530
[29]	Cristiano F, Grisolia J, Colombeau B 2000 J. Appl. Phys. 87 8420
[30]	Wang Y Z, Wang N T, Ji C, Zhang G C, Xu J 2012 Acta Phy. Sin. 61 016105 (in Chinese) [王永志, 王娜婷, 吉川, 张光超, 徐进 2012 61 016105]

施引文献

[1]	ThomPson S, Parthasarathy S 2006 MaterialsThday 9 20
[2]	Liu B C, Huang T Y 2006 China Materials Engineering Dictionary (Vol. 11) (beijing: Chemical Industry Press) p116-119 (in Chinese) [柳百成, 黄天佑 2006 中国材料工程大典(11 卷) (北京: 化学工业出版社) 第116–119页]
[3]	Bergholz W, Gilles D 2000 Phys. Stat. Sol. (b) 5 222
[4]	Shimura F, Willardson R K 1994 Academic Press 41
[5]	Isomae S, Aoki S, Watanabe K 1983 J. Appl. Phys. Lett. 55 817
[6]	Broniatowski A 1989 Phys. Rev. Lett. 62 3074
[7]	Davis J R, Rohatgi A 1980 J. Cryst. Growth. 75 67
[8]	Bains S K, Griffiths D P, Wilkes J G, Series R W, Barraclough K G 1990 J. Electrochem. Soc. 137 647
[9]	Hamet J F, Abdelaoui R, Nouet G 1990 J. Appl. Phys. 68 638
[10]	Xu J, Li F L, Yang D R 2007 Acta Phy. Sin. 4113 56 (in Chinese) [徐进, 李福龙, 杨德仁 2007 56 4113]
[11]	Zhu X, Yang D R, Li M, Chen T, Wang L, Que D L 2008 Chin. Phys. Lett. 25 651
[12]	Seibt M, Griess M, Istraov A A, Hedemann H, Sattler A 1998 Phys. Stat. Sol. (a) 166 171
[13]	Istratov A A, Weber E R 1998 Appl. Phys. A 66 123
[14]	Sachdeva R, Istratov A A, Weber E R 2001 Appl. Phys. Lett. 79 2937
[15]	Istratov A A, Weber E R 2002 J. Electrochem. Soc. 79 2397
[16]	Goetzberger A, Shockley W 1960 J. Appl. Phys. 31 1821
[17]	Miyazaki M, Sano M, Sumita S, Fujino N 1991 Jpn. J. Appl. Phys. 30 L295
[18]	Honda K, Ohsawa A, Toyokura N 1984 Appl. Phys. Lett. 45 270
[19]	Hiramoto K, Sano M, Sadamitsu S, Fujino N 1989 Jpn. J. Appl. Phys. 28 L2109
[20]	Wendt H, Cerva H, Lehmann V, Pamler W 1989 J. Appl. Phys. 65 2402
[21]	Istratov A A, Flink C, Hieslmair H 2000 Mater. Sci. Eng. B 72 99
[22]	Andrei A, Istratov A A, Weber E R 2002 J. Electrochem. Soc. G21 149
[23]	Xi Z Q, Yang D R, Xu J 2003 Appl. Phys. Lett. 83 3048
[24]	Istratova A A, Weber E R 1998 Appl. Phys. A: Mater. Sci. Pro. A66 123
[25]	Tan T Y, Gardner E E, Tice W K 1977 Appl. Phys. Lett. 30 175
[26]	Nakamura K, Saishoji T, Kubota T, Iida T, Shimanuki Y, Kotooka T 1997 J. Cryst. Growth. 180 31
[27]	Frewen T A, Sinno T 2006 Appl. Phys. Lett. 89 191903
[28]	Strunk H, Gosele U, Kolbesen B O 1979 Appl. Phys. Lett. 34 530
[29]	Cristiano F, Grisolia J, Colombeau B 2000 J. Appl. Phys. 87 8420
[30]	Wang Y Z, Wang N T, Ji C, Zhang G C, Xu J 2012 Acta Phy. Sin. 61 016105 (in Chinese) [王永志, 王娜婷, 吉川, 张光超, 徐进 2012 61 016105]

[1]	吴晨阳, 谷锦华, 冯亚阳, 薛源, 卢景霄. 椭圆偏振光谱表征单晶硅衬底上生长的非晶硅和外延硅薄膜. , 2012, 61(15): 157803. doi: 10.7498/aps.61.157803
[2]	吴太权. 微锗掺杂直拉单晶硅中的锗-空位复合体. , 2012, 61(6): 063101. doi: 10.7498/aps.61.063101
[3]	吉川, 徐进. 点缺陷对硼掺杂直拉硅单晶p/p+ 外延片中铜沉淀的影响. , 2012, 61(23): 236102. doi: 10.7498/aps.61.236102
[4]	王永志, 徐进, 王娜婷, 吉川, 张光超. 铜沉淀对直拉硅单晶中洁净区形成的影响. , 2012, 61(1): 016105. doi: 10.7498/aps.61.016105
[5]	孙鹏, 胡明, 刘博, 孙凤云, 许路加. 金属/多孔硅/单晶硅(M/PS/Si)微结构的电学特性. , 2011, 60(5): 057303. doi: 10.7498/aps.60.057303
[6]	周春兰, 王文静, 赵雷, 李海玲, 刁宏伟, 曹晓宁. 单晶硅表面均匀小尺寸金字塔制备及其特性研究. , 2010, 59(8): 5777-5783. doi: 10.7498/aps.59.5777
[7]	缪竞威, 王培禄, 朱洲森, 袁学东, 王虎, 杨朝文, 师勉恭, 缪蕾, 孙威立, 张静, 廖雪花. 氮团簇离子注入单晶硅的光致发光谱研究. , 2008, 57(4): 2174-2178. doi: 10.7498/aps.57.2174
[8]	奚光平, 马向阳, 田达晰, 曾俞衡, 宫龙飞, 杨德仁. 低温退火对重掺砷直拉硅片的氧沉淀形核的作用. , 2008, 57(11): 7108-7113. doi: 10.7498/aps.57.7108
[9]	崔灿, 马向阳, 杨德仁. 低起始温度的线性升温热处理对直拉硅中氧沉淀的影响. , 2008, 57(2): 1037-1042. doi: 10.7498/aps.57.1037
[10]	段芳莉, 王家序, 雒建斌, 温诗铸. 纳米粒子碰撞下的单晶硅表面非晶相变. , 2007, 56(11): 6552-6556. doi: 10.7498/aps.56.6552
[11]	徐进, 李福龙, 杨德仁. 直拉硅单晶中原生氧沉淀的透射电镜研究. , 2007, 56(7): 4113-4116. doi: 10.7498/aps.56.4113
[12]	段芳莉, 雒建斌, 温诗铸. 纳米粒子与单晶硅表面碰撞的反弹机理研究. , 2005, 54(6): 2832-2837. doi: 10.7498/aps.54.2832
[13]	刘明, 刘宏, 何宇亮. 纳米硅/单晶硅异质结二极管的I-V特性. , 2003, 52(11): 2875-2878. doi: 10.7498/aps.52.2875
[14]	蒋乐, 杨德仁, 余学功, 马向阳, 徐进, 阙端麟. 直拉硅中氮在高温退火过程中对氧沉淀的影响. , 2003, 52(8): 2000-2004. doi: 10.7498/aps.52.2000
[15]	李清山, 李鹏, 马玉蓉, 潘必才, 夏上达, 方容川. (单晶硅/电解液)界面对多孔硅形成初期阶段的影响. , 1996, 45(2): 244-248. doi: 10.7498/aps.45.244
[16]	陈敏锐, 沈华, 刘士毅. 掺金单晶硅特性的研究. , 1992, 41(3): 491-499. doi: 10.7498/aps.41.491
[17]	苏昉, C. LEE, P. C. TAYLOR. 单晶硅中硅氢键和氢致缺陷的电子自旋共振研究. , 1988, 37(7): 1053-1058. doi: 10.7498/aps.37.1053
[18]	高愈尊. 退火直拉硅单晶中氧沉淀和诱生缺陷的电子显微镜研究. , 1984, 33(6): 840-844. doi: 10.7498/aps.33.840
[19]	葛传珍, 徐秀英, 冯端. 直拉法生长的YAG单晶体中组分过冷引起的针状应力区和位错. , 1981, 30(2): 218-223. doi: 10.7498/aps.30.218
[20]	巴图, 何怡贞. 硅单晶中铜沉淀物的几何形态. , 1980, 29(7): 860-866. doi: 10.7498/aps.29.860

计量

文章访问数: 6431
PDF下载量: 606
被引次数: 0

姓名
邮箱
手机号码
标题
留言内容
验证码

搜索

留言板