微合金化元素Cu/Ti在L12-Al3Sc/Al界面的偏析行为

姚建刚; 宫裕祥; 江勇

doi:10.7498/aps.71.20212156

摘要

L1₂-Al₃Sc纳米析出相的热稳定性对于Al-Sc合金的耐热性意义重大. 不同溶质原子在L1₂-Al₃Sc界面的偏析行为可能对Al-Sc合金中L1₂-Al₃Sc析出相的热稳定性造成影响. 本文针对过渡族微合金化元素Cu和Ti的L1₂-Al₃Sc/Al界面偏析, 开展第一性原理能量学计算研究. 结果表明, Cu和 Ti均倾向于以替换方式偏析在界面Al侧, 但偏析驱动力和偏析占位有明显差异. 在给定温度下, 基体浓度对界面偏析量也有重要影响. 基体浓度越高, 偏析驱动力越大, 界面平衡偏析量或最大界面覆盖率越大. 温度为600 K、基体原子浓度为1%时, Ti对偏析界面的最大覆盖率可达80% (0.8 单原子层), 而Cu不超过4% (0.04 单原子层).

关键词:

Abstract

Thermal stabilities of L1₂-Al₃Sc nano-precipitates are critical for the thermotolerance of Al-Sc based alloys. Previous experiments have suggested that different alloying elements may have different segregation behaviors at the L1₂-Al₃Sc/Al interface, which can exert different influences on the thermal stability of L1₂-Al₃Sc nano-precipitates. To clarify the responsible mechanism from a quantitative approach, first-principles calculations of energetics are performed in this work, to investigate the segregation behaviors of transition-metal elements Cu and Ti at the L1₂-Al₃Sc/Al interface. The results suggest that both Cu and Ti can segregate to the interface, and substitute Al or Sc sites on its Al side with different thermodynamic driving forces. Given a temperature, segregation amount is largely determined by the initial elemental concentration in the Al matrix. The higher the segregation driving force and the initial matrix concentration are, the higher the equilibrium segregation amount (or the maximum interfacial coverage) could be. With an initial matrix atomic concentration of 1%, the maximum interfacial coverage of Ti can reach up to 80% (0.8 monolayer layer (ML)) while that of Cu is less than 4% (0.04 ML) at T = 600 K.

Keywords:

作者及机构信息

1.
烟台南山学院材料科学与工程学院, 烟台　265713

2.
中南大学材料科学与工程学院, 长沙　410083

通信作者: 江勇, yjiang@csu.edu.cn

基金项目: 国家自然科学基金(批准号: 51971249)和山东省自然科学基金(重点项目)(批准号: ZR2020KE012)资助的课题.

Authors and contacts

1.
School of Materials Science and Engineering, Yantai Nanshan University, Yantai 265713, China

2.
School of Materials Science and Engineering, Central South University, Changsha 410083, China

Corresponding author: Jiang Yong, yjiang@csu.edu.cn

Funds: Project supported by the National Natural Science Foundation of China (Grant No. 51971249) and the Key Program of the Natural Science Foundation of Shandong Province, China (Grant No. ZR2020KE012).

文章全文 : translate this paragraph

参考文献

[1]	Royset J, Ryum N 2005 Mater. Sci. Eng., A 396 409 Google Scholar
[2]	Kanresky R A, Dunand D C, Seidman D N 2009 Acta Mater. 57 4022 Google Scholar
[3]	Krug M E, Dunand D C, Seidman D N 2011 Acta Mater. 59 1700 Google Scholar
[4]	Fuller C B, Seidman D N 2005 Acta Mater. 53 5415 Google Scholar
[5]	Yoon K E, Noebe R D, Seidman D N 2007 Acta Mater. 55 1159 Google Scholar
[6]	Deschamps A, Lae L, Guyot P 2007 Acta Mater. 55 2775 Google Scholar
[7]	Jia Q, Rometsch P, Cao S, et al. 2018 Scr. Mater. 151 42 Google Scholar
[8]	Booth-Morrison C, Mao Z, Diaz M, et al. 2012 Acta Mater. 60 4740 Google Scholar
[9]	Vo N Q, Dunand D C, Seidman D N 2014 Acta Mater. 63 73 Google Scholar
[10]	Zhang C M, Xie P, Jiang Y, Zhan S, Ming W Q, Chen J H, Song K X, Zhang H 2021 Acta Metall. Sinica-Eng. Lett. 34 1277 Google Scholar
[11]	Zhang C M, Jiang Y, Cao F, Hu T, Wang Y, Yin D 2019 J. Mater. Sci. Technol. 35 930 Google Scholar
[12]	Marsha E D, David N, Seidman D N, David C D 2008 Acta Mater. 56 4369 Google Scholar
[13]	Van Dalen M E, Dunand D C, Seidman D N 2005 Acta Mater. 53 4225 Google Scholar
[14]	Gao Y H, Cao L F, Kuang J, Zhang J Y, Liu G, Sun J 2020 J. Mater. Sci. Technol. 37 38 Google Scholar
[15]	Dong W, Kresse G, Furthmüller J, et al. 1996 Phys. Rev. B 54 2157 Google Scholar
[16]	Kresse G, Joubert D 1999 Phys. Rev. B 59 1758
[17]	Leese J, Lord A E 1968 J. Appl. Phys. 39 3986 Google Scholar
[18]	Clouet E, Sanchez J M, Sigli C 2002 Phys. Rev. B 65 094105 Google Scholar
[19]	Jiang Y, Smith J R, Evans A G 2008 Appl. Phys. Lett. 92 141918 Google Scholar
[20]	Jiang Y, Xu C H, Lan G Q 2013 Trans. Nonferrous Met. Soc. China 23 180 Google Scholar
[21]	Chen Z G, Ringer S P, Zheng Z Q, Zhong J 2007 Mater. Sci. Forum. 546-549 629 Google Scholar
[22]	Kairy S K, Rouxel B, Dumbre J, Lamb J, Langan T J, Dorin T, Birbilis N 2019 Corrs. Sci. 158 108095 Google Scholar
[23]	McLean D 1957 Grain Boundaries in Metals (London: Oxford University Press) p116

施引文献

图 1 fcc-Al和L1₂-Al₃Sc体相的常用单胞结构

Fig. 1. Conventional unit cells of fcc-Al and L1₂-Al₃Sc.

下载: 全尺寸图片幻灯片

图 2 基于实验位向关系, 弛豫计算确定的L1₂-Al₃Sc/Al界面的能量最低结构. 其中红色虚线标记界面位置. 俯视图显示界面两侧最近邻原子层的配位关系为on-hollow型. 实心与空心球分别代表不同层(z = 0, 0.5)上的原子

Fig. 2. The lowest energy structure of L1₂-Al₃Sc/Al obtained by relaxation calculation using the experimental interfacial orientation relation. Dashed red lines locate the interface. The on-hollow type of interfacial coordination is manifested in the top view. The solid and open balls denote atoms at different layers z = 0 , 0.5, respectively.

下载: 全尺寸图片幻灯片

图 3 L1₂-Al₃Sc/Al界面附近各原子层上的可能偏析位置(Al位或Sc位)

Fig. 3. The possible substitutional sites (Al or Sc site) for segregated atoms at the L1₂-Al₃Sc/Al interface.

下载: 全尺寸图片幻灯片

图 4 Cu和Ti在L1₂-Al₃Sc/Al界面附近不同原子层上不同偏析位的偏析能　(a) Al位; (b) Sc位

Fig. 4. Segregation energies for Cu and Ti at different sites on different atomic layers of the L1₂-Al₃Sc /Al interface: (a) Al site; (b) Sc site.

下载: 全尺寸图片幻灯片

图 5 (a) 界面形成, (b) Ti偏析和(c) Cu偏析对应的L1₂-Al₃Sc/Al界面差分电荷密度分布

Fig. 5. Differential charge density distribution at the L1₂-Al₃Sc/Al interface induced by (a) interface formation, (b) Ti segregation, and (c) Cu segregation.

下载: 全尺寸图片幻灯片

图 6 (a) T = 600 K下不同基体原子浓度的Cu和Ti对L1₂-Al₃Sc/Al界面的平衡偏析量; (b) 图(a)选定区的放大图

Fig. 6. (a) Predicted interfacial occupations of Cu and Ti at the L1₂-Al₃Sc/Al interface under different bulk concentrations and T = 600 K; (b) the enlarged view of the selected area in Figure (a).

下载: 全尺寸图片幻灯片

表 1 界面偏析前后Cu 和Ti原子的Bader电荷分析(单位: e/atom)

Table 1. The Bader charge analysis of Cu and Ti before and after interface segregation (unit: e/atom)

Inside bulk At interface

Cu Ti Cu-Al Cu-Sc Ti-Al Ti-Sc
Bader 11.73 3.378 11.773 11.687 3.328 3.288
Net change –0.730 +0.622 –0.773 –0.687 +0.627 +0.712

下载: 导出CSV

map

[1]	Royset J, Ryum N 2005 Mater. Sci. Eng., A 396 409 Google Scholar
[2]	Kanresky R A, Dunand D C, Seidman D N 2009 Acta Mater. 57 4022 Google Scholar
[3]	Krug M E, Dunand D C, Seidman D N 2011 Acta Mater. 59 1700 Google Scholar
[4]	Fuller C B, Seidman D N 2005 Acta Mater. 53 5415 Google Scholar
[5]	Yoon K E, Noebe R D, Seidman D N 2007 Acta Mater. 55 1159 Google Scholar
[6]	Deschamps A, Lae L, Guyot P 2007 Acta Mater. 55 2775 Google Scholar
[7]	Jia Q, Rometsch P, Cao S, et al. 2018 Scr. Mater. 151 42 Google Scholar
[8]	Booth-Morrison C, Mao Z, Diaz M, et al. 2012 Acta Mater. 60 4740 Google Scholar
[9]	Vo N Q, Dunand D C, Seidman D N 2014 Acta Mater. 63 73 Google Scholar
[10]	Zhang C M, Xie P, Jiang Y, Zhan S, Ming W Q, Chen J H, Song K X, Zhang H 2021 Acta Metall. Sinica-Eng. Lett. 34 1277 Google Scholar
[11]	Zhang C M, Jiang Y, Cao F, Hu T, Wang Y, Yin D 2019 J. Mater. Sci. Technol. 35 930 Google Scholar
[12]	Marsha E D, David N, Seidman D N, David C D 2008 Acta Mater. 56 4369 Google Scholar
[13]	Van Dalen M E, Dunand D C, Seidman D N 2005 Acta Mater. 53 4225 Google Scholar
[14]	Gao Y H, Cao L F, Kuang J, Zhang J Y, Liu G, Sun J 2020 J. Mater. Sci. Technol. 37 38 Google Scholar
[15]	Dong W, Kresse G, Furthmüller J, et al. 1996 Phys. Rev. B 54 2157 Google Scholar
[16]	Kresse G, Joubert D 1999 Phys. Rev. B 59 1758
[17]	Leese J, Lord A E 1968 J. Appl. Phys. 39 3986 Google Scholar
[18]	Clouet E, Sanchez J M, Sigli C 2002 Phys. Rev. B 65 094105 Google Scholar
[19]	Jiang Y, Smith J R, Evans A G 2008 Appl. Phys. Lett. 92 141918 Google Scholar
[20]	Jiang Y, Xu C H, Lan G Q 2013 Trans. Nonferrous Met. Soc. China 23 180 Google Scholar
[21]	Chen Z G, Ringer S P, Zheng Z Q, Zhong J 2007 Mater. Sci. Forum. 546-549 629 Google Scholar
[22]	Kairy S K, Rouxel B, Dumbre J, Lamb J, Langan T J, Dorin T, Birbilis N 2019 Corrs. Sci. 158 108095 Google Scholar
[23]	McLean D 1957 Grain Boundaries in Metals (London: Oxford University Press) p116

[1]	刘郅澄, 周杰, 陈凡, 彭彪, 彭文屹, 章爱生, 邓晓华, 罗显芝, 刘日新, 刘德武, 黄雨, 阎军. Si对Inconel 718合金中γ相影响的第一性原理研究. , 2023, 72(18): 186301. doi: 10.7498/aps.72.20230583
[2]	孙士阳, 迟中波, 徐平平, 安泽宇, 张俊皓, 谭心, 任元. 金刚石(111)/Al界面形成及性能的第一性原理研究. , 2021, 70(18): 188101. doi: 10.7498/aps.70.20210572
[3]	熊辉辉, 刘昭, 张恒华, 周阳, 俞园. 合金元素对钢中NbC异质形核影响的第一性原理研究. , 2017, 66(16): 168101. doi: 10.7498/aps.66.168101
[4]	严顺涛, 姜振益. Cu掺杂对TiNi合金马氏体相变路径影响的第一性原理研究. , 2017, 66(13): 130501. doi: 10.7498/aps.66.130501
[5]	侯清玉, 李勇, 赵春旺. Al掺杂和空位对ZnO磁性影响的第一性原理研究. , 2017, 66(6): 067202. doi: 10.7498/aps.66.067202
[6]	高云亮, 朱芫江, 李进平. Al辐照损伤初期的第一性原理研究. , 2017, 66(5): 057104. doi: 10.7498/aps.66.057104
[7]	唐杰, 张国英, 鲍君善, 刘贵立, 刘春明. 杂质S对Fe/Al2O3界面结合影响的第一性原理研究. , 2014, 63(18): 187101. doi: 10.7498/aps.63.187101
[8]	周鹏力, 史茹倩, 何静芳, 郑树凯. B-Al共掺杂3C-SiC的第一性原理研究. , 2013, 62(23): 233101. doi: 10.7498/aps.62.233101
[9]	汝强, 李燕玲, 胡社军, 彭薇, 张志文. Sn3InSb4合金嵌Li性能的第一性原理研究. , 2012, 61(3): 038210. doi: 10.7498/aps.61.038210
[10]	赵荣达, 朱景川, 刘勇, 来忠红. FeAl(B2) 合金La, Ac, Sc 和 Y 元素微合金化的第一性原理研究. , 2012, 61(13): 137102. doi: 10.7498/aps.61.137102
[11]	文黎巍, 王玉梅, 裴慧霞, 丁俊. Sb系half-Heusler合金磁性及电子结构的第一性原理研究. , 2011, 60(4): 047110. doi: 10.7498/aps.60.047110
[12]	胡玉平, 平凯斌, 闫志杰, 杨雯, 宫长伟. Finemet合金析出相-Fe(Si)结构与磁性的第一性原理计算. , 2011, 60(10): 107504. doi: 10.7498/aps.60.107504
[13]	侯清玉, 赵春旺, 李继军, 王钢. Al高掺杂浓度对ZnO导电性能影响的第一性原理研究. , 2011, 60(4): 047104. doi: 10.7498/aps.60.047104
[14]	刘建军. (Zn,Al)O电子结构第一性原理计算及电导率的分析. , 2011, 60(3): 037102. doi: 10.7498/aps.60.037102
[15]	赵宇宏, 黄志伟, 李爱红, 穆彦青, 杨伟明, 侯华, 韩培德, 张素英. Nb在Ni3Al中取代行为及合金化效应的第一性原理研究. , 2011, 60(4): 047103. doi: 10.7498/aps.60.047103
[16]	罗礼进, 仲崇贵, 全宏瑞, 谭志中, 蒋青, 江学范. Heusler合金Mn2NiGe磁性形状记忆效应的第一性原理预测. , 2010, 59(11): 8037-8041. doi: 10.7498/aps.59.8037
[17]	关丽, 李强, 赵庆勋, 郭建新, 周阳, 金利涛, 耿波, 刘保亭. Al和Ni共掺ZnO光学性质的第一性原理研究. , 2009, 58(8): 5624-5631. doi: 10.7498/aps.58.5624
[18]	黄云霞, 曹全喜, 李智敏, 李桂芳, 王毓鹏, 卫云鸽. Al掺杂ZnO粉体的第一性原理计算及微波介电性质. , 2009, 58(11): 8002-8007. doi: 10.7498/aps.58.8002
[19]	朱建新, 李永华, 孟繁玲, 刘常升, 郑伟涛, 王煜明. NiTi合金的第一性原理研究. , 2008, 57(11): 7204-7209. doi: 10.7498/aps.57.7204
[20]	党宏丽, 王崇愚, 于涛. γ-TiAl中Nb和Mo合金化效应的第一性原理研究. , 2007, 56(5): 2838-2844. doi: 10.7498/aps.56.2838

计量

文章访问数: 4621
PDF下载量: 92
被引次数: 0

姓名
邮箱
手机号码
标题
留言内容
验证码

搜索

留言板

微合金化元素Cu/Ti在L1₂-Al₃Sc/Al界面的偏析行为