脉冲光纤激光修锐青铜金刚石砂轮等离子体特性研究

陈根余; 邓辉; 徐建波; 李宗根; 张玲

doi:10.7498/aps.62.144204

摘要

采用光栅光谱仪对脉冲光纤激光修锐青铜金刚石砂轮过程中产生的等离子体空间分辨发射光谱进行了测量. 研究了500–600 nm波段范围内的等离子体空间发射光谱强度随激光平均功率和脉冲重复频率的变化情况. 结果表明: 等离子体辐射光谱强度在其径向膨胀方向上距离砂轮表面约2.4 mm处达到最大值. 在局部热力学平衡假设条件下, 根据等离子体中六条铜原子谱线的相对强度, 利用Boltzmann 图法, 计算得到在不同激光功率和重复频率条件下的等离子体电子温度沿砂轮径向方向的分布规律. 实验结果表明: 在激光修锐青铜金刚石砂轮过程中, 距离砂轮表面约3 mm处等离子体电子温度出现峰值, 其温度最高可达4380 K, 且等离子体电子温度随着激光参数和空间位置的改变呈现出不同的演变规律.

关键词:

Abstract

In this paper, we present the optical emission studies of the spatial evolution of plasma during pulsed fiber laser dressing of bronze-bonded diamond grinding wheel and especially investigate the plasma light emission, which is measured through a high sensible optical spectrometer. Space-resolved spectra in a wavelength range of 500-600 nm are measured at different laser average powers and pulse repetition frequencies, and the intensity of spectral lines achieves a maximum intensity at about 2.4 mm away from the surface of the grinding wheel. The electron temperature is determined by employing the Boltzmann plot method under the assumption of local thermodynamic equilibrium using six Cu (I) lines, and the highest electronic temperature is calculated to be 4380 K at about 3 mm away from the surface of wheel. Finally the effect of the laser parameters on the electron temperature of the plasma is studied, and the results show that there are different variation laws in the electron temperature of the plasma with laser average power and pulse repetition frequency.

Keywords:

作者及机构信息

1.
湖南大学, 汽车车身先进设计制造国家重点实验室, 长沙 410082;

2.
湖南大学激光研究所, 长沙 410082

基金项目: 国家科技重大专项（批准号：2012ZX04003101）资助的课题。

Authors and contacts

1.
State Key Laboratory of Advanced Design and Manufacturing for Vehicle Body, Hunan University, Changsha 410082, China;

2.
Laser Research Institute, Hunan University, Changsha 410082, China

Funds: Project supported by the National Science and Technology Major Project of the Ministry of Science and Technology of China (Grant No. 2012ZX04003101).

参考文献

[1]	Babu N R, Radhakrishnan V 1989 J. Manuf. Sci. E-T. Asme. 111 244
[2]	Babu N R, Radhakrishnan V 1989 J. Manuf. Sci. E-T. Asme. 111 253
[3]	Dold C, Transchel R, Rabiey M, Langenstein P, Jacger C, Pude F, Kuster F, Wegener K 2011 Cirp Ann-Manuf. Techn. 60 363
[4]	Chen G Y, Mei L F, Zhang B, Yu C R, Shun K J 2010 Opt. Laser Eng. 48 295
[5]	Rabiey M, Walter C, Kuster F, Stirnimann J, Pude F, Wegener K 2012 Stroj. Vestn-J. Mech. E 58 462
[6]	Noll R 2012 Laser-Induced Breakdown Spectroscopy Fundamentals and Applications (1st Ed.) (New York: Springer-Verlag) p170
[7]	Xin R X 2011 Plasma Emission Spectrum Analysis (2nd Ed.) (Beijing: Chemical Industry Press) p18 (in Chinese) [辛仁轩 2011 等离子体发射光谱分析(第2版) (北京：化学工业出版社) 第18页]
[8]	Shaikh N M, Hafeez S, Rashid B, Mahmood S, Baig M A 2006 J. Phys. D: Appl. Phys. 39 1384
[9]	Liu Y H, Chen M, Liu X D, Cui Q Q, Zhao M W 2013 Acta Phys. Sin. 62 025203 (in Chinese) [刘月华, 陈明, 刘向东, 崔清强, 赵明文 2013 62 025203]
[10]	Drogoff B L, Margot J, Chaker M, Sabsabi M, Barthelemy O, Johnston T W, Laville S, Vidal F, Kaenel V 2001 Spectrochim. Acta B 56 987
[11]	Shaikh N M, Hafeez S, Kalyar M A, Ali R, Baig M A 2008 J. Appl. Phys. 104 103108
[12]	Liu S B, Liu Y S, He R, Chen T 2010 Acta Phys. Sin. 59 5382 ( in Chinese) [刘世炳, 刘院省, 何润, 陈涛 2010 59 5382]
[13]	Walter C, Rabiey M, Warhanek M, Warhanek M, Jochum N 2012 Cirp Ann-Manuf. Techn. 61 363
[14]	Gao X, Song X W, Guo K M, Tao H Y, Lin J Q 2011 Acta Phys. Sin. 60 025203 (in Chinese) [高勋，宋晓伟，郭凯敏，陶海岩，林景全 2011 60 025203]
[15]	Sun C W 2002 Laser Radiation Effect (1st Ed.) (Beijing: National Defence Industry Press) p93 (in Chinese) [孙承纬 2002 激光辐照效应 (第1版) (北京: 国防工业出版社) 第93页]
[16]	Milan M, Laserna J J 2001 Spectrochim. Acta Part B 56 275
[17]	Zhou X T, Li Y, Wang J D, Huang Z H 2001 IEEE T. Plasma Sci. 29 360

施引文献

[1]	Babu N R, Radhakrishnan V 1989 J. Manuf. Sci. E-T. Asme. 111 244
[2]	Babu N R, Radhakrishnan V 1989 J. Manuf. Sci. E-T. Asme. 111 253
[3]	Dold C, Transchel R, Rabiey M, Langenstein P, Jacger C, Pude F, Kuster F, Wegener K 2011 Cirp Ann-Manuf. Techn. 60 363
[4]	Chen G Y, Mei L F, Zhang B, Yu C R, Shun K J 2010 Opt. Laser Eng. 48 295
[5]	Rabiey M, Walter C, Kuster F, Stirnimann J, Pude F, Wegener K 2012 Stroj. Vestn-J. Mech. E 58 462
[6]	Noll R 2012 Laser-Induced Breakdown Spectroscopy Fundamentals and Applications (1st Ed.) (New York: Springer-Verlag) p170
[7]	Xin R X 2011 Plasma Emission Spectrum Analysis (2nd Ed.) (Beijing: Chemical Industry Press) p18 (in Chinese) [辛仁轩 2011 等离子体发射光谱分析(第2版) (北京：化学工业出版社) 第18页]
[8]	Shaikh N M, Hafeez S, Rashid B, Mahmood S, Baig M A 2006 J. Phys. D: Appl. Phys. 39 1384
[9]	Liu Y H, Chen M, Liu X D, Cui Q Q, Zhao M W 2013 Acta Phys. Sin. 62 025203 (in Chinese) [刘月华, 陈明, 刘向东, 崔清强, 赵明文 2013 62 025203]
[10]	Drogoff B L, Margot J, Chaker M, Sabsabi M, Barthelemy O, Johnston T W, Laville S, Vidal F, Kaenel V 2001 Spectrochim. Acta B 56 987
[11]	Shaikh N M, Hafeez S, Kalyar M A, Ali R, Baig M A 2008 J. Appl. Phys. 104 103108
[12]	Liu S B, Liu Y S, He R, Chen T 2010 Acta Phys. Sin. 59 5382 ( in Chinese) [刘世炳, 刘院省, 何润, 陈涛 2010 59 5382]
[13]	Walter C, Rabiey M, Warhanek M, Warhanek M, Jochum N 2012 Cirp Ann-Manuf. Techn. 61 363
[14]	Gao X, Song X W, Guo K M, Tao H Y, Lin J Q 2011 Acta Phys. Sin. 60 025203 (in Chinese) [高勋，宋晓伟，郭凯敏，陶海岩，林景全 2011 60 025203]
[15]	Sun C W 2002 Laser Radiation Effect (1st Ed.) (Beijing: National Defence Industry Press) p93 (in Chinese) [孙承纬 2002 激光辐照效应 (第1版) (北京: 国防工业出版社) 第93页]
[16]	Milan M, Laserna J J 2001 Spectrochim. Acta Part B 56 275
[17]	Zhou X T, Li Y, Wang J D, Huang Z H 2001 IEEE T. Plasma Sci. 29 360

[1]	岳东宁, 董全力, 陈民, 赵耀, 耿盼飞, 远晓辉, 盛政明, 张杰. 强激光与近临界密度等离子体相互作用中的无碰撞静电冲击波产生. , 2023, 72(11): 115202. doi: 10.7498/aps.72.20230271
[2]	张梦, 姚若河, 刘玉荣. 纳米尺度金属-氧化物半导体场效应晶体管沟道热噪声模型. , 2020, 69(5): 057101. doi: 10.7498/aps.69.20191512
[3]	张梦, 姚若河, 刘玉荣, 耿魁伟. 短沟道金属-氧化物半导体场效应晶体管的散粒噪声模型. , 2020, 69(17): 177102. doi: 10.7498/aps.69.20200497
[4]	周瑜, 操礼阳, 马晓萍, 邓丽丽, 辛煜. 脉冲射频容性耦合氩等离子体的发射探针诊断. , 2020, 69(8): 085201. doi: 10.7498/aps.69.20191864
[5]	吴忠振, 田修波, 潘锋, Ricky K. Y. Fu, 朱剑豪. 高压耦合高功率脉冲磁控溅射的增强放电效应. , 2014, 63(18): 185207. doi: 10.7498/aps.63.185207
[6]	高启, 张传飞, 周林, 李正宏, 吴泽清, 雷雨, 章春来, 祖小涛. Z箍缩Al等离子体X辐射谱线的分离及电子温度的提取. , 2014, 63(9): 095201. doi: 10.7498/aps.63.095201
[7]	洪布双, 苑涛, 邹帅, 唐中华, 徐东升, 虞一青, 王栩生, 辛煜. 电负性气体的掺入对容性耦合Ar等离子体的影响. , 2013, 62(11): 115202. doi: 10.7498/aps.62.115202
[8]	段萍, 曹安宁, 沈鸿娟, 周新维, 覃海娟, 刘金远, 卿绍伟. 电子温度对霍尔推进器等离子体鞘层特性的影响. , 2013, 62(20): 205205. doi: 10.7498/aps.62.205205
[9]	冀翔, 周朴, 王小林, 粟荣涛, 陆启生, 赵伊君. 脉冲光纤激光被动相干偏振合成研究. , 2012, 61(24): 244201. doi: 10.7498/aps.61.244201
[10]	高勋, 宋晓伟, 郭凯敏, 陶海岩, 林景全. 飞秒激光烧蚀硅表面产生等离子体的发射光谱研究. , 2011, 60(2): 025203. doi: 10.7498/aps.60.025203
[11]	蒙世坚, 李正宏, 秦义, 叶繁, 徐荣昆. X射线连续谱法诊断铝丝阵Z箍缩等离子体温度. , 2011, 60(4): 045211. doi: 10.7498/aps.60.045211
[12]	唐京武, 黄笃之, 易有根. Au激光等离子体X射线发射光谱的理论研究. , 2010, 59(11): 7769-7774. doi: 10.7498/aps.59.7769
[13]	韩晓艳, 耿新华, 侯国付, 张晓丹, 李贵君, 袁育杰, 魏长春, 孙建, 张德坤, 赵颖. 高速沉积微晶硅薄膜光发射谱的研究. , 2009, 58(2): 1344-1347. doi: 10.7498/aps.58.1344
[14]	李阳平, 刘正堂. 等离子体发射光谱诊断用于射频磁控溅射GaP薄膜的工艺参数优化. , 2009, 58(7): 5022-5028. doi: 10.7498/aps.58.5022
[15]	郭庆林, 周玉龙, 张博, 张秋琳, 张金平, 怀素芳. 减压氩气下基体对激光微等离子体电子温度的影响. , 2007, 56(9): 5318-5322. doi: 10.7498/aps.56.5318
[16]	李勇, 孙成伟, 刘志文, 张庆瑜. 磁控溅射ZnO薄膜生长的等离子体发射光谱研究. , 2006, 55(8): 4232-4237. doi: 10.7498/aps.55.4232
[17]	陈卓, 何威, 蒲以康. 电子回旋共振氩等离子体中亚稳态粒子数密度及电子温度的测量. , 2005, 54(5): 2153-2157. doi: 10.7498/aps.54.2153
[18]	黄　松, 宁兆元, 辛　煜, 甘肇强. CF4气体ICP等离子体中的双温电子特性. , 2004, 53(10): 3394-3397. doi: 10.7498/aps.53.3394
[19]	杨家敏, 丁耀南, 陈波, 郑志坚, 杨国洪, 张保汉, 王耀梅, 张文海. 等电子法测量小能量激光打靶等离子体电子温度. , 2003, 52(2): 411-414. doi: 10.7498/aps.52.411
[20]	陈波, 郑志坚, 丁永坤, 李三伟, 王耀梅. 双示踪元素X射线能谱诊断激光等离子体电子温度. , 2001, 50(4): 711-714. doi: 10.7498/aps.50.711

计量

文章访问数: 6317
PDF下载量: 540
被引次数: 0

姓名
邮箱
手机号码
标题
留言内容
验证码

搜索

留言板